Product ID:PHENOLIC VARNISH TT-Y-119
MSDS Date:12/10/1990
FSC:8010
NIIN:00-597-7856
Status Code:A
MSDS Number: CKFZH

STEVEN INDUSTRIES

39 AVENUE C
BAYONNE, NJ 07002-3417
US

Emergency Phone: 1-800-253-3436

Info Phone: 201-437-6501

Cage: 33150

STEVEN INDUSTRIES

8 BAYONNE, NJ 07002-3417 US

Telephone: 201-437-6501

Cage: 33150

MINERAL SPIRITS

CAS: 8052-41-3

RTECS: WJ8925000

OSHA PEL 500 PPM

SOLVENT NAPHTHA (PETROLEUM)

CAS: 64742-88-7

OSHA PEL 500 PPM

TUNG OIL, BODIED

CAS: 68038-50-6

LINSEED OIL, BODIED

CAS: 67746-08-1

PHENOLIC RESIN

CAS: 54579-44-1

Health Hazards Acute and Chronic:EYES: HIGH VAPOR CONCENTRATIONS MAY BE
IRRITATING. PRE-EXISTING, EYE DISORDERS (AS WELL AS SKIN AND
RESPIRATORY DISORDERS) MAY BE AGGRAVATED BY PRODUCT EXPOSURE.
SKIN: SLIGHTLY IRRITATING. PROLONGE D OR REPEATED EXPOSURE MAY
CAUSE DEFATTING AND DRYING OF THE SKIN, LEADING TO IRRITATION AND
DERMATITIS. INHALATION: HIGH VAPOR CONCENTRATIIONS MAY BE
IRRITATING TO THE NOSE, RESPIRATORY TRACT AN MAY CAUSE CENTRAL
NERVOUS SYSTEM DEPRESSION, EVIDENCED BY GIDDINESS, HEADACH,
DIZZINESS, AND NAUSEA. IN EXTREME CASES, UNCONSIOUSNDESS AND DEATH
MAY OCCUR.
Effects of Overexposure:INGESTION: INGESTION OF PRODUCT MQAY RESULT IN
VOMITING. ASPIRATION, (BREATHING) OF VOMITUS INTO THE LUNGS MUST
BE AVOIDED AS EVEN SMALL QUANTITIES MAY RESULT IN CYANOSIS (BLUISH
SKIN). IN SEVERE C ASES, DEATH MAY OCCUR.
Medical Cond Aggravated by Exposure:PRE-EXISTING EYE, SKIN, AND
RESPIRATORY DISORDERS MAY BE AGGRAVATED BY EXPOSURETO THIS PRODUCT.

First Aid:EYES: FLUSH WITH WATER FOR 15 MINUTEES WHILE HOLDING EYELIDS
OPEN. GET MEDICAL ATTENTION IF IRRITATION PERSISTS. SKIN: FLUSH
WITH WATER WHILE REMOVING CONTAMINATED CLOTHING AND SHOES, FOLLOW
BY W AXING WITH SOAP AND WATER. DO NOT REUSE CLOTHING OR SHOES
UNTIL CLEANED. IF IRRITATION PERSISTS, GET MEDICAL ATTENTION.
INGESTION: DO NOT INDUCE VOMITING, IF VOMITING OCCURES
SPONTANEOUSLY, KEEP HEAD BELOW HIPS TO PREVENT ASPIRATION OF
LIQUID INTO THE LUNGS, GET MEDICVAL ATTENTION. INHALATION:
REMOVE VICTIM TO FRESH AIR AND PROVIDE OXYGEN IF BREATHING IS
DIFFICULT, GIVE ARTIFICIAL RESPIRAT ION IF NECESSARY, GET MEDICAL
ATTENTION.

Flash Point:>40.6C, 105.F
105-114F
Extinguishing Media:WATER FOG, DRY CHEMICAL OR CO2
Fire Fighting Procedures:DO NOT ENTER CONFINED FIRE SPACE WITHOUT FULL
BUNKER GEAR (HELMET WITH FACE SHIELD,BUNKER COATS,GLOVES, AND
RUBBER BOOTS),INCLUDING POSITIVE PRESSURE NIOSH APPROVED SCBA.COOL
FIRE EXPOSED CONTAINERS WITH WATER.DO NOT USE DIRECT STREAM OF
WATER ON POOL FIRES,PRODUCT WILL FLOAT AND CAN BE REIGNITED ON
SURFACE OF WATER.
Unusual Fire/Explosion Hazard:CONTAINERS EXPOSED TO INTESNE HEAT FROM
FIRES SHOULD BE COOLED WITH WATER TP PREVENT VAPRO PRESSURE
BUILDUP WHICH COULD RESULT IN CONTAINER RUPTURE. CONTAINER AREAS
EXPOSED TO DIRECT FLAME CONTACCT SHOULD BE COOLED WITH LARGE
QUANTITIIES OF WATER AS NEEDED TO PREVENT WEAKENING OF CONTAINER
STRUCTURE.

Spill Release Procedures:LARGE SPILLS: ELIMINATE SOURCES OF
IGNITION.WEAR APPROPRIATE PROTECTIVE EQUIPMENT.SHUT OFF SOURCE OF
LEAK IF SAFE TO DO SO.DIKE&CONTAIN.REMOVE W/VACUUM
TRUCKS/PUMP-STORAGE/SALVAGE VESSELS.SOAK UP RES IDUE W/ABSORBENT
SUCH AS CLAY,SAND/OTHER SUITABLE MATERIAL,PLACE IN NONLEAKING
CONAINERS&SEAL TIGHTLY FOR PROPER DISPOSAL.FLUSH AREA
W/WATER-REMOVE TRACE RESIDUE.DISPOSE OF FLUSH SOLUTION AS ABOVE.
Neutralizing Agent:SMALL SPILLS:TAKE UP W/ABSORBENT MATERIAL&PLACE IN
NONLEAKING CONTAINERS FOR PROPER DISPOSAL.

Handling and Storage Precautions:KEEP CONAINERS CLOSED WHEN NOT IN
USE.USE ADEQUATE VENTILATION.CONTAINERS,EVEN EMPTY&CONTAIN
EXPLOSIVE VAPORS.DO NOT CUT,DRILL,GRIND,WELD/PERFORM SIMILAR
OPERATIONS NEAR CONTIANERS.
Other Precautions:KEEP LIQUID&VAPOR AWAY F/HEAT,SPARKS&FLAME.HOT
SURFACES?IGNITE PRODUCT IN ABSENCE OF SPARK&FLAME.EXTINGUISH PILOT
LIGHTS,CIGARETTES,&TURN OFF SOURCES OF IGNITION PRIOR-USE UNTIL ALL
VAPORS ARE GONE.VA PORS?ACCUMULLATTE&TRAVEL-IGNITION SOURCES FAR
F/HANDLING SITE.FLASH FIRE CAN RESULT.GROUND CONTAINER S&EQUIPMENT.

Respiratory Protection:IF EXPOSURE MAY OR DOES EXCEED OCCUPATIONAL
EXPOSURE LIMITS, USE A NIOSH APPROVED REPSIRATOR AS REQUIRED TO
PREVENT OVEREXPOSURE. IN ACCORD WITH 29 CFR 1910.134, USE EITHER
AN ATMOSPHERE-SUPPLYING RE SPIRATOR OR AN AIR PURIFYING RESPIRATTOR
FOR ORGANIC VAPORS.
Ventilation:USE EXPLOSION PROOF VENTILATION AS REQUIRED TO CONTROL
VAPOR CONCENTRATIONS WITHIN SUGGESTED PEL/STEL LIMITATIONS.
Protective Gloves:CHEMICAL RESISTANT GLOVES AND OTHER CLOTHING REQUIRED
AS TO MINIMIZE EXPOSURE.
Eye Protection:SAFETY GLASSES OR CHEMICAL SPLASH GOGGLES AS
APPROPRIATE.
Other Protective Equipment:SAFETY SHOWER, EYE BATH AND WASHING
FACILITIES SHOULD BE AVAILABLE.
Work Hygienic Practices:MINIMIZE SKIN CCONTACT. WASH WITH SOAP AND
WATER BEFORE EATING, DRINKING, SMOKING OR USING TOILET FACILITIES.
NO SMOKING WHERE MATERIAL IS USED OR STORED.
Supplemental Safety and Health
FOR WORK ON TANK, REFER TO OCCUPAIONAL SAFETY AND HEALTH ADMINISTRATION
REGULATIONS ANSI Z49.1, AND OTHER GOVERNMENTAL AND INDUSTRUAL
REFERENCES PERTAINING TO CLEAN-UP, WELDING, OR OTHER CONTEMPLATED
OPERATIONS.

Boiling Pt:>161.7C, 323.F
B.P. Text:323=390F
Vapor Pres:3.O
Vapor Density:.AIR
Volatile Org Content %:359
Spec Gravity:0.90
Evaporation Rate & Reference:0.13 (BUTYL ACETATE = 1)
Solubility in Water:INOLUBLE
Appearance and Odor:YELLOW LIQUID/PETROLEUM ODIOR.
Percent Volatiles by Volume:46.0

Stability Indicator/Materials to Avoid:YES
Stability Condition to Avoid:AVOID HEAT, FLAME AND CONTACT WITH STRONG
OXIDIZING AGENS SUCH AS LIQUID CHLORINE, CONENTRATED OXYGEN, SODIUM
OR CALCIUM HYPOCHLORITE.
Hazardous Decomposition Products:CO, AND UNIDENTIFIED ORGANIC COMPOUNDS
DURING COMBUSTION.

Waste Disposal Methods:SEAL CONTAINERS, LABEL PROPERLY AND DISPATCH TO
APPROVED WASTE DISPOSAL FACILITY. ASSURE COMPLIANCE WITH ALL
LOCAL, STATE AND FEDERAL REGULATIONS.

Toxicological Information:MALE RATS EXPOSED FOR 90 DAYS, BY INHALATION
OF VAPORS OF SOLVENTS SIMILAR TO COMPONENT 1, SHOWED EVIDENCE OF
KIDNEY DAMAGE. THE RELEVANCE OF THIS EFFECCT TO HUMANS IS UNKNOWN.
IN ONE OF THE STUDIES , A LOW GRADE ANEMIA WAS ALSO OBSERVED. RATS
EXPOSED FOR FOUR MONTHS TO 1700 PPM OF A SOLVENT SIMILAR TO
COMPONENT 2 SHOWED EVIDENCE OF MILD DAMAGE TO THE LIVER. LUNGS AND
KIDNEYS.*

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.

Ecological:THESE EFFECTS WERE NOT SEEN IN RATS EXPOSED FOR 1 YEAR TO
350 PPM OF ANOTHER SIMILAR SOLVENT,RATS EXPOSED TO VAPORS OF A
SIMILAR SOLVENT DURING PREGNANCY SHOWED EMBRY/FETOTOXICITY AT
CONCENTRATIONS PR ODUCING MATERIAL TOXICITY.NOTE TO PHYSICIAN: IF
MORE THAN 2.0 ML/KG HAS BEEN INGESTED AND VOMITING HAS NOT
OCCURRED, APHESIS SHOULD BE INDUCED WITH SUPERVISION. KEEP VICTIMS
HEAD BELOW HIPS TO PREVE NT ASPIRATION. IF SYMPTOMS SUCH AS LOSS
OF GAG REFLEX, CONVULSIONS OR UNCONSIIUOSNESS OCCUR BEFORE EMISIS,
GASTRIC LAVAGE USING A CUFFED ENDOTRACHEAL TUBE SHOULD BE
CONSIDERED.

Transport Information:UN# 1263 SHIPPING NAME: PAINT. HAZARD CLASS:
FLAMMABLE LIQUID.

SARA Title III Information:FEDERAL REGULATION REPORTABLE QUANTITY:
UNDER EPA-RCRA (40 CFR 261,21), THIS PRODUCT IS CLASSIFIED AS AN
OIL UNDER SECTION 311. SPILLS INTO OR LEADING INTO SURFACE WATES
THAT CAUSE A SHEEN MUST BE R EPORTED TO THE NATIONAL RESPONSE
CENTER 1-800-424-8802. EPA-COMPREHENSIVE ENVIRONMENTAL RESPONSE
COMPENSATION AND LIAQBILITY ACT. UNDER EPA-CERCLA (SUPERFUND)
RELEASE TO LAND, OR WATER MAY BE REPORT ABLE TO THE NATIONAL
RESPONSE CENTER 1-800-424-8802. (CIRCUMSTANCES SURROUNDING THE
RELEASE AND CLEAN-UP DETERMINE REPORTABLE QUANTITY.
State Regulatory Information: